2004 NISSAN TITAN Engine And Engine Cooling Exhaust System problems & defects.

NISSAN TITAN Engine And Engine Cooling Exhaust System problems : 25.

Exhaust Manifold Cracked And Leaking. nissan Dealership Diagnosed Problem, But nissan Refused To Fix Problem. I Started Before 80k Miles, But I Didn’t Know Emission’s Had 80k Warranty, nissan Refused To Fix At 84k. Loud Exhaust Noise At Start-up And While Driving, Fumes(carbon Monoxide) Leaking Into Cabin When Idling In Traffic. *tr

Mileage was 77000 miles. Vehicle Identification Number (VIN):1N6AA06B54N. NISSAN TITAN 2004 problem was reported in BROKEN ARROW, OK. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 10 mph.

Mar 01, 2008

The Tailpipe Fell Off Of My Truck. Resulting In The Hot Exhaust To Be Vented Onto A Rear Wiring Harness And Thus Melting It. Along With The Melted Wiring Harnesses, The Ecm And Mass Airflow Sensor Were Shorted Out And Need To Be Replaced. This Will Be Over $2000 To Fix And Will Be Paid For Straight Out Of My Pocket. The Warranty Does Not Cover Exhaust Because It Supposedly Is A Regularly Maintained Part. This Truck Is A 2wd Model With 305/50×20 Wheels/tires , So It Obviously Is Not Used For Off-road Purposes Nor Has It Been Used To Tow Anything. When The Tailpipe Broke, The Truck Was Being Driven Down A Smooth Black Top Highway And Nothing Was Ran Over In The Road Such As An Animal Or Debris That Would Cause The Tailpipe To Fall Off. I Bought This Truck Used But With Only 30k Miles On It And Only Drove It 1500 Miles Since Purchasing It. *tr

0 person(s) were injured. 0 person(s) died. Mileage was 32000 miles. NISSAN TITAN 2004 problem was reported in PAW PAW, IL. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 60 mph.

June 08, 2008

The Vehicle ( A 2004 nissan titan) Has 30 Thousand Plus Miles,carefully Maintained (no Salt) And Was Pulling A 7500 Pound Boat On Pa I-79 When It Lost All Power,including All Lights (including Rear And Hazard) .this Resulted In A Fire Which Totally Disabled The Entire Vehicle. The Tail Pipe Had Fallen Off And Burned Dozens Of Electrical Wires. This Manufacturing Defect Has Been Reported Numerous Times On The Net And To Dealers. It Should Strongly Be Noted That Had The Same Incident Occurred On Ny I-90 Where There Is No Safe Place To Pull Off Or At Night Anywhere, Many Lives Would Have Been Lost. This Defect Must Receive Immediate Attention. nissan Has Refused To Acknowledge The Defect Or Pay For Repairs. *tr

Vehicle was on fire. 0 person(s) were injured. 0 person(s) died. Mileage was 37000 miles. Vehicle Identification Number (VIN):1N6AA06B44N. NISSAN TITAN 2004 problem was reported in PROSPECT, PA. Accident was reported to Police. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 55 mph.

Aug 25, 2008

I Have Had An Odd Exhaust Sound From My nissan titan For Over 18 Months. When I Finally Took It Into The Dealer Both Exhaust Manifolds Were Cracked And Repairs Cost $1400.00. I Was Told A The Dealer And At Several Muffler Shops That This Is A Very Common Defect Due The Cast Nature Of The Manifold And The Excessive Weight Of The Catalytic Converter Welded Onto The Manifold. The Replacement Part Were A New Design And The Dealer Said They Will Not Crack. Since My Truck Had 105,000 Miles On It When The Service Was Done There Is No Warranty Coverage. I Feel That This Is A Design Flaw With The 2004 And 2005 nissan titan Pickups And The Cost Of Repairs Should Be Borne By nissan And Not By The Consumer. I Am Hoping That There Will Be A Class Action Suite Filed On The Consumer’s Behalf Either By An Individual, The State Or The Federal Government. *tr

Mileage was 75000 miles. Vehicle Identification Number (VIN):1N6AA07B24N. NISSAN TITAN 2004 problem was reported in HYDESVILLE, CA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control.

Oct 20, 2008

My 2004 nissan titan Rear Diff Seals Leak And Has Caused A Brake Failure. I Pulled Out Of My Driveway And Was Driving Down The Road When All Of A Sudden My Rear End Locks Up. It Took A Few Moments To Get Her Going Again In Reverse. I Jacked It Up And Removed The Tires And Removed The Rotors. The Pad On The Emergency Brake System Fail Off. It Still Had Plenty Of Pad Left On It. My Father Looked At It And Noticed The Fluid Leaking From My Rear End. He Told Me That Probably Caused The Failure Due To The Contamination. Replaced The Pad And Added Some Oiled To The Rear End. I Have Researched This Issue Online And Found Numerous Complaints About This And Other Brake Failures Also. There Should Be A Recall For This Issue. My Exhaust Manifold Leaks Also. I Am Replacing It Too. This Is A Known Issue With The titans. This May Be Of More Concern With The Epa. They Have Been Know To Crack. *tr

Mileage was 90000 miles. Vehicle Identification Number (VIN):1N6AA07B54N. NISSAN TITAN 2004 problem was reported in BERKELEY SPRINGS, WV. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 35 mph.

Nov 15, 2009

Heard Exhaust Leak In engine At About 85,000 Miles. Manifold Leak Was Confirmed At 101,000 When Brought In For A Transmission Issue. Not Covered Under Warranty. Reviewed Many Technical Forums Where The Exhaust Manifold Is Being Reported As Cracked On Countless titans. This Is A Manufacturer’s Defect, And The Cost Should Not Be Relayed To The Consumer At A Significant Dollar Amount. *tr

Mileage was 85000 miles. Vehicle Identification Number (VIN):1N6AA06B74N. NISSAN TITAN 2004 problem was reported in NEW RICHMOND, WI. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 0 mph.

Nov 20, 2009

Exhaust Manifold Warps After About 80k Miles, Creating An Exhaust Leak. If It Develops Before The 80k Mile Emissions Warranty, It Will Be Covered. Most Develop After The Warranty. I Own An ’04 And An ’05 nissan titan. The ’05 Exhaust Leak Was Fixed At 78k Miles With 1 New Exhaust Manifold And Some Crossover Piping. The ’04 Started At 88k Miles And The Dealership Has Not Helped With The Problem With The Exception Of Estimating $1300 To Repair. *tr

Mileage was 90000 miles. Vehicle Identification Number (VIN):1N6AA06A44N. NISSAN TITAN 2004 problem was reported in OKLAHOMA CITY, OK. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. VEHICLE SPEED: 60 mph.

Feb 21, 2010

I Purchased My 2004 nissan titan In April 2010, I Took The Vehicle In For Service On May 6, 2010 And Was Told My Exhaust Manifolds Are Leaking. The Warranty Is 8 Yr/ 80k, I Have 82k On My titan. The Exhaust Fumes Leak Into The Cab Causing Nausea And Dizziness. This Is A Safety Issue. The Dealer Won’t Replace Them, Because They Are Out Of Warranty. The Replacement Cost Is $2000.00. *tr

Mileage was 82200 miles. Vehicle Identification Number (VIN):1N6AA07B84N. NISSAN TITAN 2004 problem was reported in STERLING, CO. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. VEHICLE SPEED: 50 mph.

May 06, 2010

Purchased A 2004 nissan titan In April 2010 With 82k On The engine. In May 2010, I Brought The Truck In For A Recall. The Vehicle Had 82,528 Miles On It. The Dealer Discovered That Both Exhaust Manifolds Were Leaking And Quoted My $1800.00 For The Repair. I Now Smell A Strong Odor Of Exhaust Fumes Coming Into The Cab. The Fumes Cause Nausea And Headaches. I Have Contacted nissan And They Refuse To Fix The Problem. I Have Researched This Topic Online And Found This To Be A Very Common Defect Among 2004 Thru 2007 nissan titans. There Has Yet To Be A Recall For This Issue. I Continually See People Reporting This Issue On Internet Forums. This Is A Known Defective Part. The Leak Is Also Hazardous To The Environment. I Have Reported This Issue To The Epa As Well. *tr

Mileage was 82528 miles. Vehicle Identification Number (VIN):1N6AA07B84N. NISSAN TITAN 2004 problem was reported in STERLING, CO. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. NISSAN TITAN 2004 drive type:4WD. VEHICLE SPEED: 0 mph.

May 06, 2010

Exhaust Manifolds Cracked And Leaking Exhaust Into Passenger Compartment. *tr

Mileage was 101000 miles. Vehicle Identification Number (VIN):1N6AA06A24N. NISSAN TITAN 2004 problem was reported in ANDERSON, SC. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. VEHICLE SPEED: 0 mph.

Oct 28, 2010

2004 nissan titan Exhaust Manifold Cracked. Both Sides, Causing Exhaust Fumes Into The Cabin Of The Vehicle. nissan Refusing To Settle The Claim Due To Vehicle Being Over Warranty Mileage Of 8/80k. Step Up And Make This A Recall For nissan!!! *tr

Mileage was 85000 miles. Vehicle Identification Number (VIN):1N6AA07B04N. NISSAN TITAN 2004 problem was reported in GLENS FALLS, NY. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. VEHICLE SPEED: 0 mph.

Nov 21, 2010

The Contact Owns A 2004 nissan titan. The Contact Stated That The Exhaust Manifold Cracked Which Caused The Exhaust Fumes To Escape Into The Vehicle. The Vehicle Was Taken To An Authorized Dealer Who Stated That If The Manifold Was Replaced But The Catalytic Converter Was Not, The Manifold Would Crack Again. The Catalytic Converter Was Replaced. The Vin Was Unavailable. The Failure Mileage Was Approximately 120,000 And The Current Mileage Was Approximately 121,000.

Mileage was 120000 miles. NISSAN TITAN 2004 problem was reported in EVERETT, WA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 0 mph.

July 15, 2010

Exhaust Manifold Crack. Exhaust Fumes Smelled In The Cabin. *tr

Mileage was 81600 miles. Vehicle Identification Number (VIN):1N6AA07B74N. NISSAN TITAN 2004 problem was reported in MADISON, WI. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. NISSAN TITAN 2004 drive type:4WD. VEHICLE SPEED: 25 mph.

Mar 10, 2010

Cracked Exhaust Manifolds. *tr

NISSAN TITAN 2004 problem was reported in WANTAGH, NY. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control.

Oct 20, 2010

The Contact Owns A 2004 nissan titan. The Contact Started The Ignition And Heard A Loud Ticking Noise On The Outside Of The Vehicle. The Failure Would Occur When The Vehicle Was In Motion And During The engine Initial Start-up. The Vehicle Was Taken To An Authorized Dealer For Diagnosis And They Informed That The Exhaust Manifold Exhibited A Severe Crack. The Vehicle Was Not Repaired. The Failure Mileage Was Approximately 66,000. The Vin Was Unavailable.

Mileage was 66000 miles. NISSAN TITAN 2004 problem was reported in ST. PORT LUCIE, FL. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 0 mph.

June 05, 2010

The Contact Owns A 2004 nissan titan. While The Vehicle Was Being Inspected By The Dealer He Was Informed That The Vehicle Had A Cracked Exhaust Manifold. The Contact Called The Manufacturer And Was Advised That The Repair Was Not Under Warranty And There Were No Recalls. The Vehicle Was Not Repaired. The Failure Mileage Was 69,000 And The Current Mileage Was 69,323.

Mileage was 69000 miles. Vehicle Identification Number (VIN):1N6AA06B34N. NISSAN TITAN 2004 problem was reported in CAPE GIRARDEAU, MO. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 0 mph.

Dec 08, 2010

Exhaust Manifolds In nissan titans Around The Year Of ’04 Are Cracking When The Shouldn’t Be With Just Mild Wear And Tear On The Car. Dealers Are Saying Its Not A Dangerous Problem So They Cant Recall It But With A Cracked Exhaust Manifold Co Can And Often Does Leak Into The Cabin. *tr

Mileage was 95000 miles. NISSAN TITAN 2004 problem was reported in EVERGREEN, CO. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control.

Dec 10, 2010

2004 nissan titan – Know Issue With Exhaust Manifolds That Leak. This Leak Or Crack In The Exhaust Manifold Causes The engine Computer To Run Full Rich All The Time. This Creates An Unsafe Condition Inside The Cab Of The Vehicle With Noxious Exhaust Fumes And Health Concerns. Not To Mention The Fuel Mileage Is Almost Cut In Half As I Have Calculated. My Truck Will Be On It’s Third Set Of Manifolds. The First Two Sets Of Replacements Were Covered Under The Federal Emissions Warrant Up To 80k Miles But That Has Expired At This Point. nissan Is Aware Of This Issue And From Information I Have Gathered The Have Updated The Design Of The Manifolds. I Might Add That The Catalytic Converters Are Directly Connected To These Manifolds. I Cannot Stress Enough The Safety Concerns With Exhaust Fumes Constantly Entering Inside This Cab – I Drive To Work With Headaches And Nausea And Burning Eyes Every Day! *tr

Mileage was 110000 miles. Vehicle Identification Number (VIN):1N6AA06B74N. NISSAN TITAN 2004 problem was reported in CHELMSFORD, MA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. NISSAN TITAN 2004 drive type:4WD.

Jan 20, 2011

The Contact Owns A 2004 nissan titan. The Contact Stated That The Catalytic Converter Came Apart And Was Sucked Up In The Intake Of The engine While Driving 5 Mph. The Vehicle Was Taken To The Dealer Who Informed Him That The engine Would Need Replacing. The Vehicle Was Repaired By An Independent Mechanic. The Manufacturer Was Contacted Who Offered No Assistance. The Failure Mileage Was 175,000.

Mileage was 175000 miles. Vehicle Identification Number (VIN):1N6AA07A54N. NISSAN TITAN 2004 problem was reported in ADDIS, LA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 5 mph.

Jan 26, 2008

2004 titan. Connection Failed At The Flanges Welded To The Exhaust Pipe And The Muffler Extension At The Right Rear Wheel Area. The Exhaust Pipe And The Muffler Extension Are In Good Condition. The Failure Was Confined To The Flange Attachments. Failure Resulted In Hot Air/gases Melting A Critical Wire Harness That Is Attached Along The Frame Beam To Carry Electrics To The Rear Of Vehicle. The Right Rear Wheel Speed Sensor Was Damaged. The Wires Shorted, Causing The Failure Of Underhood Electrical Components. Immediate Consequence Was The engine Shut Down With Loss Of Power Steering And Power Brakes And All Other Components Relying On Power From The Alternator. The Experienced Driver Was Able To Coast The Vehicle To A Stop Along A Busy Interstate Highway. Long Range Consequences Were The Replacement Of The titan‘s Wire Bundles And Electronic Components At Considerable Cost. nissan Has Not, To Date, Explained Why This Simple Connection Failed, Why A Wire Harness Was Located Close To This Heat Source, Why The Wire Harness Was Not Protected Against Heat Damage, Why The Electrical Damage Was Not Limited By A Fuse, Why titan Owners Were Not Notified Of This Potential Catastrophic Problem And Why nissan Dealers Did Not Inspect And Notify titan Owners Of This Issue During Other Routine Maintenance At Their Facilities. *tr

Mileage was 69935 miles. Vehicle Identification Number (VIN):1N6AA07BX4N. NISSAN TITAN 2004 problem was reported in PONTOON BEACH, IL. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. NISSAN TITAN 2004 drive type:4WD. VEHICLE SPEED: 60 mph.

Mar 16, 2010

The Contact Owns A 2004 nissan titan. While Driving Approximately 30 Mph, The Contact Heard A Clicking Noise And Smelled Exhaust Fumes Inside Of The Vehicle. The Vehicle Was Taken To An Independent Mechanic Where They Informed The Contact That The Exhaust Manifold Was Cracked. The Vehicle Was Not Repaired. The Exhaust Fumes Progressively Became Worse Over A Period Of Time. The Manufacturer Was Not Made Aware Of The Problem. The Failure Mileage Was Approximately 50,000. The Vin Was Unavailable.

Mileage was 50000 miles. NISSAN TITAN 2004 problem was reported in LEESBURG, GA. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 30 mph.

May 10, 2009

The Contact Owns A 2004 nissan titan. The Contact Stated That Fumes Emitted Into The Vehicle. The Vehicle Was Taken To A Dealer Who Diagnosed That There Were Two Cracked Manifolds Which Needed To Be Replaced. The Manufacturer Was Made Aware Of The Failure And Filed A Report Stating That The Regional Consumer Specialist Would Contact Her At A Later Date. The Vehicle Was Not Repaired. The Failure Mileage Was 85,000 And The Current Mileage Was 100,000.

Mileage was 85000 miles. Vehicle Identification Number (VIN):1N6AA06B84N. NISSAN TITAN 2004 problem was reported in AMAWALK, NY. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control.

Nov 20, 2010

The Contact Owns A 2004 nissan titan. When Starting The Vehicle, The Contact Heard A Noise Coming From The engine. The Vehicle Was Taken To The Dealer Who Stated That The Exhaust Manifold Was Cracked On Both Sides. The Manufacturer Was Not Notified Nor Was The Vehicle Repaired. The Approximate Failure Mileage Was 80,000.

Mileage was 80000 miles. Vehicle Identification Number (VIN):1N6AA07B74N. NISSAN TITAN 2004 problem was reported in SPANISH FORK, UT. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 0 mph.

July 23, 2011

The Contact Owns A 2004 nissan titan. The Contact Stated That The Exhaust Manifold Was Leaking And Causing The Smell Of Fumes To Enter The Vehicle. As A Result, The Odor Was Making It Very Difficult To Drive The Vehicle. The Vehicle Was Taken To An Authorized Dealer Where The Contact Was Informed That The Vehicle Needed A New Exhaust Manifold. The Vehicle Was Not Repaired. The Failure Mileage Was 104,000. The Vin Was Unavailable.

Mileage was 104000 miles. NISSAN TITAN 2004 problem was reported in CLANCY, MT. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. VEHICLE SPEED: 0 mph.

Nov 12, 2010

The Contact Owns A 2004 nissan titan. The Contact Stated That While Driving At Various Speeds, The Vehicle Exhibited A Loud Noise. The Vehicle Was Taken To A Dealer And They Advised Him That The Driver Side Manifold Was Fractured And Needed To Be Replaced. The Vehicle Was Not Repaired. The Manufacturer Was Contacted And They Offered To Pay For Labor Costs. The Failure Mileage Was Approximately 80,000. Updated 11/16/2011 *ln

0 person(s) were injured. 0 person(s) died. Mileage was 80000 miles. Vehicle Identification Number (VIN):1N6AA06B04N. NISSAN TITAN 2004 problem was reported in IDYLLWILD, CA. Vehicle was purchased on 20040101. Vehicle was not using ANTI-LOCK BRAKES. Vehicle was not using Cruise Control. Vehicle had 8 CYLINDERS. NISSAN TITAN 2004 TRANSMISSION TYPE: AUTO.

Apr 01, 2011

2004 NISSAN TITAN problems and complaints, and up-to-date recall information. If you are researching a used NISSAN TITAN, driving a 2004 NISSAN TITAN, or if you are planning to purchase one, review owner-reported Engine And Engine Cooling Exhaust System problems and defects.

Post Author: nissanproblem

Leave a Reply

Your email address will not be published. Required fields are marked *

You may use these HTML tags and attributes: <a href="" title=""> <abbr title=""> <acronym title=""> <b> <blockquote cite=""> <cite> <code> <del datetime=""> <em> <i> <q cite=""> <strike> <strong>